Chimney Repair Cost - You See the Footage Before You Get a Price

Every visit starts with

Level 1 sweep and inspection to the NFPA 211 annual standard - flue, crown, cap, and flashing checked and photographed

Worth knowing

Chimney sweep logs do not sweep chimneys. They loosen some creosote - which then falls where a brush and vacuum still have to collect it.

Styles & brands we work with

‹

›

Before & after – our own jobs

‹

BeforeAfter

BeforeAfter

BeforeAfter

›

How Much Does Chimney Repair Cost in Staten Island?

Chimney repair in Staten Island typically runs between $150 and $4,500, depending on what needs to be fixed and how far the damage has progressed. Minor work – a cracked crown patch or a new cap – sits at the lower end. A full chimney rebuild or liner replacement pushes toward the top. Most homeowners in Staten Island pay somewhere between $350 and $1,200 for a single repair visit that addresses one problem completely.

Chimney Repair Cost Breakdown (2026)

The numbers below reflect what Hearthstone Chimney Co. actually quotes on Staten Island jobs in 2026. Prices vary based on chimney height, access, material condition, and whether the work turns up surprises once we get into it – which is why we do a Level-2 camera inspection before we quote anything structural.

What Drives Cost Up or Down

The single biggest variable is how early you catch the problem. A crown with a hairline crack repaired in autumn costs a few hundred dollars. That same crack, left through two Staten Island winters – with freeze-thaw cycles pulling water deeper into the masonry every season – can split the crown wide open and migrate damage down into the flue. At that point you’re looking at a liner repair on top of a full crown replacement, and the bill triples.

Chimney height matters, too. A single-story ranch in Arden Heights has a shorter flue and easier roofline access than a two-and-a-half story colonial in Emerson Hill. More ladder height means more time on the job and, sometimes, a staging requirement – both of which add to labor cost. Interior access also plays a role: a cleanout door at the base of the flue speeds things up; no cleanout means more setup time.

Material selection moves the number as well. A painted steel cap from the hardware store runs less than a welded stainless Gelco cap, but the stainless cap will likely outlast the homeowner’s tenure in the house. We use professional-grade materials from Gelco, Famco, DuraFlex, HeatShield, Olympia Chimney, and Copperfield on every job – not builder-grade substitutes – and we’re direct about the price difference and what you get for it.

What Affects Chimney Repair Pricing in Staten Island

• Age and construction of the chimney: Staten Island has a large stock of pre-1960 brick chimneys, particularly in neighborhoods like St. George, Stapleton, and West Brighton. Older chimneys were often built with softer lime-based mortar that erodes faster than modern Portland-cement mixes. Repointing those joints requires matching the original mortar hardness – use something too rigid and you crack the surrounding brick. That extra step takes more skill and time, which is reflected in the price.
• Freeze-thaw damage from Staten Island winters: Water gets into small cracks, freezes, expands, and forces the crack wider. By March, what looked like surface spalling in October has become a structural concern. Homes in the northern end of the island – Port Richmond, Mariners Harbor, Howland Hook – tend to see more of this because they catch more wind and hold moisture longer in winter. Catching it early is the only thing that keeps the repair bill manageable.
• Salt air and coastal exposure: The South Shore communities – Tottenville, Charleston, Huguenot, Prince’s Bay – sit close enough to the water that salt air accelerates mortar decay and corrodes metal components faster than inland locations. Caps, flashing, and damper hardware on these chimneys wear out sooner. A stainless steel cap that might last 20 years in Heartland Village might need attention in 12 to 15 years two miles from the beach.
• Roof pitch and access difficulty: Steep-pitched roofs common in certain Mid-Island Tudor and colonial styles require additional safety precautions and, on some jobs, roof jacks or staging. This is not something we cut corners on – working safely at height is non-negotiable, and the added setup is reflected honestly in the estimate.
• Number of flues: Some older Staten Island homes have chimneys that serve both a fireplace and a boiler or furnace through separate flues inside the same masonry structure. More flues mean more liner area to inspect and potentially repair. A two-flue chimney isn’t twice the work, but it’s meaningfully more.
• Extent of damage found during inspection: This is the honest answer most companies skip over. We do a Level-2 camera inspection before quoting structural work because the eye can’t see what’s happening inside the flue. We’ve gone out to quote a crown repair in New Springville and found a cracked flue tile six feet down that the homeowner had no idea about. Pricing work without that information means either giving you a number that changes later, or padding the estimate to cover unknowns. We’d rather show you the photos and quote what we actually see.

How to Save on Chimney Repair

Schedule an Inspection Before Problems Get Bigger

The chimney industry’s standard recommendation is an annual inspection, and there’s a practical reason for it: small problems in masonry don’t stay small. A $200 crown resurfacing job today can become a $1,500 tuckpointing job next year if water gets into the joints and the winter does its work. On Staten Island specifically, the combination of older housing stock and coastal weather means chimneys age faster than homeowners expect. An inspection is the cheapest form of repair there is.

Take Advantage of Standing Offers

Hearthstone Chimney Co. has four standing offers that don’t change and don’t expire:

• $50 Off Any Repair Over $250 – applied at the time of service, no coupon required.
• Free Second Opinion on any written estimate you’ve already received from another company. If you’ve been handed a quote that seems high or vague, bring it to us and we’ll look at it honestly.
• $89 Seasonal Tune-Up – covers a visual inspection, cleaning assessment, and basic component check. A good starting point if you haven’t had the chimney looked at in a few years.
• 5% Senior and Veteran Discount – permanent and applied to any service. No paperwork beyond proof of eligibility.

Don’t Wait for a Problem to Become an Emergency

Emergency chimney work – repairs done under time pressure because water is coming in or a cap has blown off – costs more than the same work scheduled on a normal visit. Not because we charge an emergency premium on everything, but because rushed scheduling and same-week access create real logistics costs. If you notice something off – efflorescence on the brick, a draft that doesn’t feel right, a cap that’s shifted – calling to schedule a look costs nothing and often saves real money.

Ask for an Itemized Estimate

Upfront, itemized pricing protects you. When a contractor gives you a single lump number without breaking it down, you have no way of knowing whether you’re paying for what you actually need. Our estimates list labor and materials separately so you can see exactly where the money is going. The number on the estimate is the number on the invoice – no add-ons at the end of the job.

Bundle Related Work

If your chimney needs a new cap and the crown has a crack, having both done in one visit saves a service call charge versus scheduling two separate appointments. Same goes for tuckpointing and waterproofing – the sealant application takes about 30 minutes once the mortar work is done, but scheduling it as a separate visit adds a trip charge. Ask us what makes sense to combine when we’re on site.

To get a straight estimate on your chimney, call (516) 613-3035. We answer every call with a live person, and estimates are free.

Common Chimney Repair Scenarios in Staten Island

The Post-Storm Cap Loss

Wind events on Staten Island – especially fall nor’easters that track up the coast – knock caps off chimneys every season. We get a cluster of calls every October and November from homeowners in Annadale, Eltingville, and along the South Shore after a storm comes through. A missing cap opens the flue to rain, birds, and debris immediately. A replacement Gelco or Famco stainless steel cap, properly sized and installed, typically runs $150 to $350 and can usually be done same day on a normal schedule.

The Slow-Water Problem

More often than not, the homeowner doesn’t know there’s a water problem until they see a stain on the ceiling near the chimney or notice crumbling plaster on the wall beside the firebox. By then, water has been working its way in through a failed crown, cracked flashing, or open mortar joints for at least one season, possibly two. In Westerleigh and Castleton Corners, where we see a lot of 1940s and 1950s brick colonials, this pattern shows up regularly. The repair depends on where the water is entering – which is exactly what the Level-2 inspection is for – but budget $500 to $1,800 for a water-entry repair once the source is identified and addressed properly.

The Boiler-Flue Liner Issue

When a gas or oil boiler is vented through a masonry chimney – common in older Staten Island homes where the original oil system was updated but the chimney wasn’t relined – the flue is almost certainly the wrong size for the appliance. Oversized flues on modern, efficient boilers cause condensation inside the liner, which breaks down the masonry from the inside. We see this regularly in older sections of St. George and Stapleton. A properly sized DuraFlex stainless liner solves it: expect $1,800 to $3,200 depending on flue length and whether insulation wrap is required by the appliance manufacturer.

The Pre-Sale Inspection Find

Home inspectors in Staten Island flag chimneys regularly, and buyers use those flags as negotiating points. We get calls from sellers who need a quick, documented repair to keep a deal on track. We can usually get on site within a few days, produce a written report with photos, and complete straightforward repairs in a single visit. If a real estate attorney or buyer’s agent needs documentation, the Level-2 report with photos gives them something solid to work with.

Our Approach: Inspect First, Then Quote

Russell Haines founded Hearthstone Chimney Co. in 1984, and the inspection-before-quoting principle has been standard practice since the beginning. It’s not complicated: you can’t honestly price a repair you haven’t fully seen. Our Level-2 camera inspection looks at the full length of the flue – not just what’s visible from the firebox opening or the top of the chimney – and produces photos the homeowner can see and a plain-English written report with a verdict. No technical jargon, no vague findings, no “we recommend further evaluation.”

If we find something, we explain what it is, why it matters, and what it costs to fix. If we don’t find anything that needs immediate attention, we tell you that too. We’ve been doing this long enough to know that a straight answer is worth more than a padded estimate, and homeowners in Staten Island have a good instinct for when they’re being worked.

Every repair we complete comes with the 90-Day Done Right Promise in writing. If the work isn’t right, we come back and make it right – no paperwork, no arguing, no expiration date on the conversation. That commitment is governed by what we call the K.E.Y.S. values: Krafted right, Every time, Your home first, Standing behind it. It’s not a marketing slogan. It’s the job description.

For a closer look at everything we handle, visit our Chimney Repair in Staten Island service page. And if you want to understand who we are and how we work, the home page is a good place to start.

FAQs – Chimney Repair Cost in Staten Island

How much does chimney repair cost in Staten Island?

Most chimney repairs in Staten Island cost between $150 and $4,500, with the majority of single-problem jobs landing in the $350 to $1,200 range. Simple work – a cap replacement, a crown patch, a damper swap – runs toward the low end. Liner installations, major tuckpointing, and partial or full rebuilds push toward the high end. The fastest way to get a number specific to your chimney is to call (516) 613-3035 for a free estimate.

How much does chimney tuckpointing cost in Staten Island?

Mortar repointing on Staten Island chimneys typically runs $300 to $1,500, priced by the linear foot of deteriorated mortar joint. A chimney that’s lost mortar in a few courses above the roofline will sit toward the low end. A full-height chimney with joints eroded from ground level up – which we see on some of the older brick chimneys in St. George and Stapleton – will be closer to the top of that range or beyond it. Mortar matching matters on these jobs: using a mix that’s harder than the original brick causes the brick face to spall. We get that right the first time. Call (516) 613-3035 for a free look and a straight number.

Is it cheaper to repair or replace a chimney in Staten Island?

Repair is almost always cheaper when the damage is limited to one or two components – a failed crown, a deteriorated liner, crumbling mortar joints in the top section. A partial rebuild above the roofline runs $1,500 to $3,500. A full rebuild from the foundation up runs $3,000 to $4,500 or more and is only necessary when the masonry is structurally compromised at the base. The honest answer comes from an inspection: we look at what’s actually failing before recommending anything. Call (516) 613-3035 and we’ll tell you what we see.

How much does chimney liner replacement cost in Staten Island?

A new flexible stainless liner – DuraFlex, sized and insulated to the appliance – runs $1,800 to $3,800 on Staten Island. Length of the flue, liner diameter, and whether the appliance manufacturer requires an insulation wrap all affect the final number. HeatShield liner resurfacing, which repairs an existing masonry flue from the inside without installing a metal liner, runs $900 to $2,200 and is a good option when the masonry is sound but the mortar joints inside the flue are failing. Call (516) 613-3035 for a free estimate – we’ll scope the flue first so the quote reflects what’s actually there.

How long does a chimney repair take in Staten Island?

Most single-repair jobs – cap replacement, crown resurfacing, repointing a limited section, damper replacement – are done in one visit, typically two to four hours. More involved work like a full liner installation or a partial rebuild might run a full day. Full chimney rebuilds can take two to three days depending on height and scope. Our technicians complete most jobs in a single visit, and we don’t leave a job half-done. If a job needs to come back, we schedule it before we leave the driveway.

Does Hearthstone offer a warranty on chimney repairs?

Yes. Every repair is covered by the 90-Day Done Right Promise in writing. If the work isn’t right – by any reasonable standard – we come back and fix it. No paperwork, no arguing, no charge. That applies to labor and to materials. We use professional-grade products from DuraFlex, HeatShield, Gelco, Olympia Chimney, Famco, and Copperfield because they hold up, and because our name is on the work long after the truck leaves the driveway.

Key Takeaways

• Chimney repair in Staten Island ranges from about $150 for a simple cap replacement to $4,500 or more for a full rebuild.
• Most homeowners pay $350 to $1,200 for a single repair that fully resolves one problem.
• Staten Island’s older brick housing stock, freeze-thaw winters, and coastal salt air accelerate chimney wear – earlier repairs are almost always cheaper repairs.
• A Level-2 camera inspection before any structural quote is not an upsell; it’s how you avoid getting a price that changes once work begins.
• Hearthstone Chimney Co. has been serving Staten Island since 1984. Russell Haines leads the company and stands behind every job with the 90-Day Done Right Promise in writing.
• Four standing offers: $50 Off Any Repair Over $250, Free Second Opinion, $89 Seasonal Tune-Up, and a permanent 5% Senior and Veteran Discount.
• Estimates are free. Call (516) 613-3035 – a live person picks up every time.

Ready to Get a Straight Answer on Your Chimney?

If your chimney needs attention – or you’re not sure whether it does – the next step is a conversation. Call (516) 613-3035 and a live person will answer. We’ll ask a few questions about what you’re seeing, schedule a time that works, and come out with the tools to give you a real inspection and a real number. No vague estimates, no surprises on the invoice. The number we quote is the number you pay. That’s been the standard at Hearthstone Chimney Co. since Russell Haines started the company in 1984, and it hasn’t changed.

Pricing reflects the Staten Island market as of 2026. Hearthstone Chimney Co. offers free estimates – call (516) 613-3035.

Written by Russell Haines, Owner at Hearthstone Chimney Co., serving Staten Island, NY since 1984.